Hand Stripping Furniture
Directions for HAND Stripping. - Work with plenty of ventilation, safety goggles or glases, and skin protection. Stay out of the direct sun and stay protected from wind or strong drafts if working outside.
- Work in small areas starting at the top and working to the bottom of the piece. Apply a generous coat of gel remover. Brush on in one direction. Do not brush back and forth.
- Use soft wood scrapers and/or Steel Wool to remove crinkled finish and spent stripper.Repeat the above process until all layers of old finish are gone. On fine work, when the piece has all the finish gone and looks ready to refinish, go over it again with one last coat of stripper carefully working from top to bottom and removing stripper with Liberon #00 steel wool to ensure all traces of finish are lifted from the pores of the wood. Neutralize the wood surface by washing the piece down with Naphtha followed by Lacquer Thinner, if the piece is newer and in very good condition, a washdown with Lacquer Thinner may suffice.
- Let the stripped piece dry thoroughly for at least 24 hours to 48 hours for softer woods or pieces that required long soaking to clean off all the finish. Refinish promptly to seal and protect from humidity changes and environmental contamination.
HINTS & TIPS: - Test to see if a through cleaning with Liberon's Wood Cleaner & Wax remover might eliminate the need to totally strip and refinish the piece.
- Use the right stripper for the finish being removed. (Determine finish type with solvents.)
- Use solvent washable strippers or paint removers.
- Avoid water washable removers to minimize grain raising, staining problems, and softening of glues or adhesives and the subsequent lifting of veneers and loosening of joinery.
- Avoid Metal Scrapers of any kind, wood fibers softened from the remover are easily compressed by hard metal edges. These sometimes apparently invisible `indents' can later show up after staining or even under clear coat finishes.
- DO NOT Sand a stripped surface. Sanding removes oxidized fibres, the natural distressing wear and ageing collectors refer to as patina. Upon refinishing uneven and splotchy effects result from the `windows' sanded into the surface. Often sanded areas of stripped wood will not take stain or finish the same as the unsanded part of the same piece. Therefore, for instance, sanding of a table leaf usually means sanding the entire top and remaining leaves. The surface was carefully prepared for the previous finish. Successful refinishing will be much easier if we disturb the wood the very least possible, in the finish removal process. If an area is badly damaged as to require sanding; proceed with care and be aware of the increased finish work that can be created by sanding. Lightly raised grain can in some cases be stained, sealed with sanding sealer, and then sanded instead of sanding on the bare wood.
- Partially strip (on Lacquers): On some pieces a top for instance might be all that really needs to be stripped and totally refinished. Proper cleaning and touch-up of dings, dents, and blemishes on sides or underpinnings with an overfinish of the existing finish might give a very professional result. In the right instance this can be a more profitable for the finisher and offer an affordable option for the customer.
- Use wax paper laid over the remover to slow evaporation and prolong working time. On difficult finishes and in drafty work areas each application of remover can then do more work.
- To lift paint or finish retained in the grain of open pored timber, despite repeated applications of remover, try the following. Let the surface dry for a day, apply a liberal coat of 1 pound cut shellac & and allow to dry throughly then try a coat of remover to lift the shellac and the adhered finish out of the pores. The wax paper trick above helps here also. On hard cases repeat the shellac and remover steps above if positive results come from the first application.
Refinishing Stripped surfaces are always a little more problematic than finishing on new wood. Generally Pigment Wiping Stains are the best choice for coloring on the stripped surface. Lacquer shading stains and lacquer colorants blended into sanding sealer and build coats are a good bet for color correcting. Use amber lacquer on medium to darker woods or stains to give a richer and homogeneous continuity to the piece. On very light timber and on light colors use water -white lacquer or for the very clearest non-yellowing finish use CAB-Acrylic lacquer. IMPORTANT: PROTECT EYES and SKIN. Always test products in an inconspicuous place to check compatibility and end results. Companion Materials & Supplies: - Safety Glasses or face shield for eye protection.
- Heavy duty rubber stripping gloves.
- Apron; preferably rubber or rubber coated.
- WOODEN scrapers (NOT putty knives or metal scrapers)
- Stripping BRUSH: stripper resistant plastic for getting into carvings and mouldig.
- STEEL WOOL:
- #0 or #1 for light clear finishes, #1 or #2 for paints, &
- #3 or #4 for very heavy built up layers of finish.
- Rags.
PRECAUTION: Do not leave impregnated rags wadded or stacked in bundles as these can burst into spontaneous fire. Dispose of rags and waste in accordance with local regulations; or lay rags out flat preferably outside, to dry so as to avoid any fire hazard. About The Author Steve Hattrick Proprietor 10 years experience Konteaki Furniture Importers http://www.hattrick-furniture.co.uk
Related News
|
 |
|
|
RELATED ARTICLES
Making the Most of a Small Bathroom
In bathroom terms at least, bigger doesn't have to be better ? It's all just a case of making the most of the modest proportions you're presented with! And what's more, designing a bathroom that's small on space usage but big on style and functionality should be a lot more fun.
Planning Permission Tips UK - Free Design Advice In The UK - How And Where To Get It
Isn't it funny how people shelve projects for the new year - perhaps the new year feels like a fresh canvas or something - I don't know. Many potential clients I saw in Q4 of last year our now coming through as confirmed commissions - it's a funny old world with no rhyme or reason...
Improving Your Bottom Line Through Vastu
The design of your office and home has a great influence on your financial success. If your work or living environments are in harmony with nature they have a positive affect on your prosperity.
Planning Permission Tips UK - Conservatories - Dispelling a Myth
It's now well into the new year and the residential development scene has got off to a good start again. All this talk about 'slow down' certainly hasn't affected peoples desire to improve rather than move. Building Design Agents are often the first barometer within the building trade of any ups or downs in trends and I certainly haven't noticed any lessening of work.
Tiles are the Foundation Stone for Your Stylish Bathroom!
Tiles can increase the value of any home. Ceramic tiles, mosaic tile, floor tile all add an extra quality to your home. Tile can be found throughout a home from the kitchen, bathrooms, and even the flooring. Tiles are widely available in most home improvement stores and also in specialty stores throughout the company. Finding the right tile for a home with the right color, design, and even pattern can seem overwhelming. But, the results of this project can be beneficial for years to come.
Rustic Stone House Signs
You may own a remarkably constructed, attractive house that is perfect from every angle. The outside of the house is designed to demand a second look from anyone passing by. So it's important that people know the name of the particularly well-constructed house. Also anyone visiting the house should easily be able to locate it hence putting up your house name or street address in a legible and presentable manner is of utmost importance.
Planning Permission UK - Tactics if Appealing to the DOE for a Planning Refusal
Tactics of Appealing to the DOE - There will be times in any Design Agents career when a clients scheme will be refused Planning Permission. Fortunately, our experience is now at a point when we can normally forecast these schemes & steer the client away from that design solution. Clients that wish to pursue these contentious schemes are at least forewarned of the likely outcome so that we can formulate a 'plan of attack' for the next phase of the extension or development. Many clients seem to want to drive head first to the Appeal route directly after refusal - IN MOST CASES THIS IS NOT A WISE DECISION & IT CAN AFFECT THE FUTURE DEVELOPMENT VIABILITY OF YOUR SITE.
An Interview with Design Psychology Expert Jeanette Fisher
Interview with Jeanette Fisher by Gary Anderson, of www.abciowa.com
Home Improvement Projects That Really Pay Off
Many of us watch TV shows and see the miraculous transformation of homes and gardens by professionals and amateur do-it-yourselfers. Is it really that easy, we ask ourselves. Could I do it? Where do I begin? What home improvement projects will generate the biggest increase in the value of my home?
Styles And Varieties Of Locking Mailboxes For Sale
Locking mailboxes made from durable, weatherproof
materials are highly desirable due to the built in safety
features and the long-lasting exterior. Your mail will
arrive safely and be waiting for you upon your return when
you purchase and install a locking mailbox on your
property. You will find locking mailboxes for sale in a
variety of styles, including large to medium size that can
be bricked in to match upscale communities and contractors.
Locking mailboxes give you the security you need to go out
of town for several days or go on vacation and you will
know that you mail will be safe upon your return.
A Few Simple Facts About Gas And Electric Heating Systems
To make your home more energy efficient, you need to understand the energy efficiency of different types of heating and cooling systems. Many times people are confused by inaccurate information they receive from manufacturers and sellers of heating and cooling equipment.
But all you need to know in order to make wise decisions when purchasing this equipment are a few simple facts.
CCTV for the Home
Securing your property is one of the growing domestic issues in the UK today. Some research suggests that at least one home is broken into every minute. Therefore, protecting homes and properties has become a priority and the advent of Closed Circuit Televisions or CCTVs is timely to say the least and can be employed for this purpose.
Five Easy Ways to Give Your Kitchen Designer Wow!
A beautiful kitchen is the heart of any home (even for those of us who spend most of our cooking time around the microwave!) Time spent together in the kitchen can bring a family closer together and make wonderful memories (although my own memories of doing dishes as a teenager are less than pleasant - something about dishwater being *disgusting!*) Turning your plain kitchen into something special isn*t as hard as you might think. Here are a few simple ideas which can make your kitchen a designer showcase.
Buy Area Rugs on the Web? What a Site!
After spending hundreds of dollars on your favorite Picasso print, the idea of buying it online, anticipating its delivery, tossing it on the floor and going for a stroll seems unimaginable. But there is a form of art that you can walk all over: the area rug.
Do You Have a Master Bedroom? You Shouldnt! Tips for Remodeling Your Bedroom
The word "master" is an antiquated term that suggests control, domination, and inequality, and in today's cooperative partner and/or single parent household, the label "master suite" has become obsolete. In that light, master bedrooms would more properly be called "main bedrooms" in today's society.
Plastic Applied to the Picnic Table?
There are many styles of picnic tables on the market, but what kind of material is best for durability and safety? Powder coating has been an accepted coated finish for years and there are several reasons why. The coating look great, you can have most any color you want, they are friendly to the environment and efficient to produce. The powder is applied in liquid form so it goes on similar to painting. If you need to have flexibility and strength against impacts, this type of finish would no be the best. Some type of PVC coating is the finish of choice when flexibility is key.
3 Great Reasons to Shop for Home Lighting Online
If you are a consumer who knows just what brand or style of lighting fixtures you are looking to buy, the internet can save you money. Conversely, if you are just learning about what lighting fixtures, interior and exterior, are available for your home, the internet is a great place to get educated.
Ways to Heat Your Water
Water heating options
Kitchen Remodel - How to Survive
You have decided to make the plunge and begin to plan your kitchen remodeling project. There are so many questions and you're not sure where to start. There are some steps you should follow to help you survive what is probably the most intense home improvement project you will ever embark on.
Repairing Your Own Machine Components
Many industrial concerns have workshops of their own. For the
repair of worn shafts, the lathe machine is excellent. Keyway
slots can be machined by using a milling machine, while a
shaping machine can do machining of large flat areas. A
drilling machine does drilling of holes.
|
