The Motors Best Friend


The starting current of motor can become 3 to 6 times the normal running current! That's normal for motors. The motor can experience this high current for a period ranging from 20 to 50 seconds.

A fuse will not be very useful in protecting a motor from this type of overload condition. A selected fuse large enough to permit passage of the necessary starting current would give little or no protection against overheating of the windings under normal running load conditions. The same case happens for the circuit breaker.

Overload relays offer protection of motors that is both compatible with the starting current of the circuit, and the requirement of protection in the event of overload running condition.

These conditions need to be adjustable. A particular motor requiring 56 seconds starting time under normal load will suffer serious damage if the rotor locks and the motor is not tripped in 20 seconds. Another motor may be able to withstand 25 percent overload for 30 minutes. A hermetically sealed compressor motor may burn in 3 minutes at 25 percent overload!

Good protection against overheating of the motor windings can be obtained from temperature monitoring protector devices that are embedded into the motor windings. These do not protect the motor itself, but act as sensors to trigger a temperature control circuit to stop the motor.

A thermal overload relay, however, uses a heating element to heat up a bimetallic strip so that it can trip a latch that will open the motor control circuit. This action will disconnect the motor from the line.

For reliable operation, the overload relay must be located at the same temperature environment as the motor. The heating effect of the bimetallic strip mechanism is supposed to represent the heating of the motor windings.

Melting alloy overload relays calibrated by the manufacturer are considered the most reliable of all the thermal overload protective devices. However, more commonly used is the bimetallic overload relays because the tripping current setting can be adjusted.

All the overload relays have one major limitation - because they operate on line current, they do not directly sense the motor temperatures. For normal steady running conditions, this poses no problem at all.

However, when a motor starts and stops frequently, the relay may not completely protect the motor. Why is that so?

During the motor running, the relay temperature follows the motor temperature closely. When the motor is off, the relay tends to cool off at a faster rate because of its lower mass. After a number of starts and stops, the temperatures of the relay and the motor may drift further and further apart. Eventually the motor becomes hot, and yet the relay does not trip because it is still cool. The motor burns.

Frequent starting and stopping of motors is no good both electrically and mechanically.

Until next time...

Are You Stumped by Complicated Electrical Calculations? Useful Electro-Technology Questions & Answers available for all electrical installations.

Many years of working experience in Marine, Facilities, Construction has given the author material for writing e-books and articles related to engineering, and management. Subscribe to facworld ezine

More information at Marine Engineer and M & E Engineer







Related News



AG Van Hollen: Home improvement company and owner charged with ... - Wisbusiness.com

AG Van Hollen: Home improvement company and owner charged with ...
Wisbusiness.com, WI -Nov 19, 2008
The complaint alleges that in November, 2005 defendants entered into a $55250 home improvement contract with a Menasha couple promising, among other things, ...

Home improvement retail sinks on data - Forbes

Medill Reports

Home improvement retail sinks on data
Forbes, NY -Nov 19, 2008
AP , 11.19.08, 03:13 PM EST Shares of home improvement chains dipped Wednesday after the federal government said construction of new homes and apartments ...
How home improvement chains fared in 3rd quarterThe Associated Press
Home Depot Posts 31% Fall in Net Income, Cuts ViewWall Street Journal
Tough economy takes toll on Home DepotAtlanta Journal Constitution
CNNMoney.com - Bloomberg
all 529 news articles

Sector roundup: Solar, home improvement - Forbes

Sector roundup: Solar, home improvement
Forbes, NY -Nov 19, 2008
CHICAGO (AP) - Shares of home improvement chains dipped Wednesday after the federal government said construction of new homes and apartments slowed at a ...

Ahead of the Bell: Home improvement retailers - Forbes

Ahead of the Bell: Home improvement retailers
Forbes, NY -Nov 19, 2008
The home improvement retailers are part of a sector that has "competitive dynamics, stable gross margins through the downturn, and clear cyclicality ...
Home Depot Is Not in a FixBarron's
all 6 news articles

Kudzu.com Survey Reveals DIY Projects Are an Unreliable Way to ... - MarketWatch

Kudzu.com Survey Reveals DIY Projects Are an Unreliable Way to ...
MarketWatch -Nov 19, 2008
In fact, one in four (25%) Americans have hired a professional to fix or finish a home improvement project they first attempted themselves. ...


The Home Depot Declares Third Quarter Dividend of 22.5 Cents - La Voz de Dalton

The Home Depot Declares Third Quarter Dividend of 22.5 Cents
La Voz de Dalton, GA -9 hours ago
The Home Depot is the world's largest home improvement specialty retailer, with 2270 retail stores in all 50 states, the District of Columbia, Puerto Rico, ...
The Home Depot Declares Third Quarter Dividend of 22.5 CentsPR Newswire (press release)
all 13 news articles

Raven Industries Announces Higher Sales and Earnings for Third Quarter - MarketWatch

RTT News

Raven Industries Announces Higher Sales and Earnings for Third Quarter
MarketWatch -Nov 19, 2008
"These include lower levels of new home construction and home improvements negatively affecting our bed-control deliveries, and the loss of a significant ...
The Home Depot Announces Third Quarter ResultsEarthtimes (press release)
Raven Industries Announces Higher Sales and Earnings for Third QuarterSunHerald.com
Patrick Industries, Inc. Announces Third Quarter 2008 Financial ...PR-CANADA.net (press release)
Earthtimes (press release)
all 424 news articles

The Home Depot Declares Third Quarter Dividend of 22.5 Cents - MarketWatch

The Home Depot Declares Third Quarter Dividend of 22.5 Cents
MarketWatch -12 hours ago
The Home Depot is the world's largest home improvement specialty retailer, with 2270 retail stores in all 50 states, the District of Columbia, Puerto Rico, ...

Endeavour Docks at Space Station on Home-Improvement Mission - Bloomberg

Canada.com

Endeavour Docks at Space Station on Home-Improvement Mission
Bloomberg -Nov 16, 2008
16 (Bloomberg) -- NASA’s space shuttle Endeavour docked with the International Space Station today just after 5 pm New York time on a home-improvement...
Video: Space Shuttle Endeavour Blasts Into Night SkyAssociatedPress
Shuttle Endeavour docks with ISS on 'home-improvement' missionRIA Novosti
US shuttle Endeavour lifts off on 'home improvement' missionEastDay.com
Space Fellowship - International Herald Tribune
all 5,713 news articles

Economic Downturn Sparks New Home Improvement Trend - MarketWatch

Economic Downturn Sparks New Home Improvement Trend
MarketWatch -Nov 18, 2008
With the harsh reality of uncertain economic times, and the average consumer shouldering $10000 or more in credit card debt, a new trend in home improvement...